<p>For your injectors, I recommend witchhunter performance. I'm on my phone, but this should be the link <a href="http://www.witchhunter.com">http://www.witchhunter.com</a>. You simply print off an order firm, full it out and ship off your injectors. I think it was about $20 per injector and they flow test them, clean them, replace seals and give you the results. </p>

<p>Chad</p>
<div class="gmail_quote">On Mar 10, 2014 10:31 PM, "rheorojo@F" <<a href="mailto:rheorojo@frontier.com">rheorojo@frontier.com</a>> wrote:<br type="attribution"><blockquote class="gmail_quote" style="margin:0 0 0 .8ex;border-left:1px #ccc solid;padding-left:1ex">
Got the distributor ready to go. I'll include the capacitor also as it is a little different, but is a Bosch. The arc point is visible on the barrel of the unit. I've been slowly checking the fuel economy issues, to rule out components. I replaced the voltage regulator with the new electronic version, and installed a small volt meter direct from the battery. I get a solid 14.1 at mid rpm's. I tried disconnecting the throttle position sensor and didn't feel a lot of change. The fuel situation started a few years back after I was advised my old injectors were faulty. Since then it's been around 20 mpg. I got taken on that one. I have another set but as of now have not attacked them. They have been sitting dry for several years and I'm uncertain on the proper procedure to get them in. I've read the seals can dry out and then they leak. I don't want to go there so I'm a deer in the headlights. I don't see any obvious signs of wrong injectors such as fouled/lean running plugs, or<br>

 excess smoke/vapor when it's running. The exhaust doesn't smell like unburned gas so I'm not convinced the injectors are wrong. Just a suspicion. Besides I really enjoy driving the car even though it's not right, I just keep reading and thinking and tinkering. Last time I checked the fuel pressure was at 28 psi. I haven't changed the fuel filter in a while so that is next.  This forum is a must for me with my coffee every morning.<br>

Tim<br>
On Mar 10, 2014, at 9:20 AM, Jim Adney wrote:<br>
<br>
> On 10 Mar 2014 at 8:22, rheorojo@F wrote:<br>
><br>
>> Once I get past this I'll be back cogitating about why I have poor<br>
>> mileage.<br>
><br>
> First thing to check would be your charging system regulating<br>
> voltage. With the engine still running at medium rpm after a warmup<br>
> drive, the voltage measured at the battery should be 14.1 - 14.4 V.<br>
> It will measure about 1/2 V higher at the generator or ~1/2 V lower<br>
> at the fuse box.<br>
><br>
> If it's less than 13.5 V at the battery, replace the voltage<br>
> regulator with a Bosch 30-019. If you can't find one locally, I have<br>
> them for $45.<br>
><br>
> Low system voltage makes the FI run rich.<br>
><br>
> --<br>
> *******************************<br>
> Jim Adney, <a href="mailto:jadney@vwtype3.org">jadney@vwtype3.org</a><br>
> Madison, Wisconsin, USA<br>
> *******************************<br>
><br>
> _______________________________________________<br>
> VWType3.Org mailing list - <a href="mailto:type3@vwtype3.org">type3@vwtype3.org</a><br>
> <a href="http://lists.vwtype3.org/listinfo.cgi/type3-vwtype3.org" target="_blank">http://lists.vwtype3.org/listinfo.cgi/type3-vwtype3.org</a><br>
> Contact <a href="mailto:gregm@vwtype3.org">gregm@vwtype3.org</a> if you need help with the list.<br>
<br>
_______________________________________________<br>
VWType3.Org mailing list - <a href="mailto:type3@vwtype3.org">type3@vwtype3.org</a><br>
<a href="http://lists.vwtype3.org/listinfo.cgi/type3-vwtype3.org" target="_blank">http://lists.vwtype3.org/listinfo.cgi/type3-vwtype3.org</a><br>
Contact <a href="mailto:gregm@vwtype3.org">gregm@vwtype3.org</a> if you need help with the list.<br>
</blockquote></div>