<div dir="ltr"><div>---------- Forwarded message ----------  <br></div>From: Jim Adney <<a href="mailto:jadney@vwtype3.org" target="_blank">jadney@vwtype3.org</a>><br>To: <a href="mailto:type3@vwtype3.org" target="_blank">type3@vwtype3.org</a><br>Cc: <br>Bcc: <br>Date: Thu, 11 Jun 2020 09:08:21 -0500<br>Subject: Re: [T3] 71 Squareback MT/FI - Intermittent Engine Stopping<br>On 10 Jun 2020 at 19:37, Wisconsin Spryers wrote:<br><div><br></div><div>>> While holding the switch in the momentary "prime" position I was able<br>>> to start the engine and it continued running when I released the switch.<br><br>Sorry, I guess I wasn't clear: This test would only be useful during one of<br>those times when the engine dies and won't restart. If holding the primer<br>switch allows the reluctant engine to start, your fuel pump relay is at fault.<br><br>>>> While driving around the block this morning, the engine stopped </div><div>>>> and it didn't restart. I held down the primer switch and the engine </div><div>>>> still did not start. In addition, I did not get the 2 clicks from the </div><div>>>> Fuel Pump Relay - only 1 click under the rear seat. </div><div>>>> After about 1 hour tried again...same results: No clicks from the</div><div>>>> Fuel Pump Relay, 1 click from under the rear seat, engine not</div><div>>>> starting. I removed the Fuel Pump Relay (Bosch, Made in</div><div>>>> Germany, VW Part No: 311 906 061) and around the </div><div>>>> center terminal (labeled 30/51) there is some dis-coloration - blackish</div><div>>>> color. Bad Fuel Pump Relay? Any other tests I can perform?</div><div><br></div><div>Thanks,</div><div><br></div><div>-- Richard Spryer</div><div><br><br><br><br></div></div>