[T3] Regulator going down again!
BilDylJ at aol.com
BilDylJ at aol.com
Sat May 19 05:43:15 PDT 2012
Hi Keith
I bought 12 volt generator brushes for VW in Florida at
Advance Auto Parts " no shipping charge"
In a message dated 5/15/2012 7:28:52 P.M. Eastern Daylight Time,
topnotch at nycap.rr.com writes:
Driving around town now in the rain, lights on, wipers on, and things are
getting worse again. No COLD generator light when I first start it like
before but now the electronic Bosch regulator is starting to give an idle
light, and this morning when I arrived at work I had to get it up close to
3K RPM with the lights and wipers OFF to get the generator light out! Now,
it IS charging at those RPM's even if the light is on but at idle its
almost
as if its not full-fielding the generator when it should. Drove home, nice
bright light even though it WAS charging and the system voltage was good,
then, about half way the light would go out but a little while later its on
again and now its NOT charging unless I get about 3K RPM. Got home,
squeezed the brushes on the generator and all was well, so now it's the
generator again! These brushes are new and not worn down and this is one
of
the 2 generators Ive been using with no problems for 20 years.
Is it possible that the regulator is damaging the generator? This
generator
still looks fine and both brushes still look/feel new but needed a squeeze
to make good contact again after only about 1000 miles on them
I will say that I got 2MPG MORE on the return trip from PA with the 14V and
although there was some tail wind involved for about 60 miles that wouldn't
have accounted for all of it. I also noticed that it was detonating on
the
hills though, something I haven't heard before with the new stepped heads..
Should I adjust it a smidge richer or just go up to 89 Octane??
Anybody have a set of 12V generator brushes they'd sell me without charging
me $10 in shipping to send them? I need to rebuild another core I have if
Im going to feel good about the invasion trip.
Thanks
Keith
-------------- next part --------------
An HTML attachment was scrubbed...
URL:
<http://lists.vwtype3.org/private.cgi/type3-vwtype3.org/attachments/20120515/c9a841aa/attachment.htm>
_______________________________________________
VWType3.Org mailing list - type3 at vwtype3.org
http://lists.vwtype3.org/listinfo.cgi/type3-vwtype3.org
Contact gregm at vwtype3.org if you need help with the list.
-------------- next part --------------
An HTML attachment was scrubbed...
URL: <http://lists.vwtype3.org/private.cgi/type3-vwtype3.org/attachments/20120519/f7564023/attachment.htm>
More information about the type3-vwtype3.org
mailing list